Vectra B Caravan Turbo

Diskutiere Vectra B Caravan Turbo im Vectra - Umbau-Projekte unserer User Forum im Bereich Opel Vectra Problemforum; Pozdrav drug! Auto je vrhunski složen i virujem da ide jako dobro :151: Koji je izvorno motor bio unutra? Možeš li dat malo detaljnije...
ma men

ma men

Doppel-As
Dabei seit
25.05.2010
Beiträge
220
Ort
Kroatien
Pozdrav drug!

Auto je vrhunski složen i virujem da ide jako dobro :151: Koji je izvorno motor bio unutra?

Možeš li dat malo detaljnije informacija o mehaničkim dijelovima koje si ugrađiva, tipa getriba, poluosovine, nosači i slično?
 
opcar

opcar

Mitglied
Themenstarter
Dabei seit
28.11.2010
Beiträge
32
Ort
Zemun, Serbien
Ich danke Ihnen allen für Ihre Kommentare :D.

Hier ein paar neue Bilder:

 
Silver Arrow

Silver Arrow

Gelber Engel
Dabei seit
09.01.2006
Beiträge
3.061
Alter
45
Ort
RLP
Nach wie vor,schönes Auto!

Already nice Car!

**Have Fun** ;(
 
opcar

opcar

Mitglied
Themenstarter
Dabei seit
28.11.2010
Beiträge
32
Ort
Zemun, Serbien
Vielen dank Silver Arrow,

Hier wird am Cockpit bei Nacht aussehen ;(



best regards,
Danijel
 
TS-Schranz

TS-Schranz

Routinier
Dabei seit
15.09.2009
Beiträge
510
Alter
45
Ort
Erfurt
wow

realy nice car

very well done job
 
opcar

opcar

Mitglied
Themenstarter
Dabei seit
28.11.2010
Beiträge
32
Ort
Zemun, Serbien
@TS Schranz -Thank you very much :)



Pozdrav drug!

Auto je vrhunski složen i virujem da ide jako dobro :151: Koji je izvorno motor bio unutra?

Možeš li dat malo detaljnije informacija o mehaničkim dijelovima koje si ugrađiva, tipa getriba, poluosovine, nosači i slično?

Hvala ti, unutra je izvorno bio X20XEV.

Naravno da mogu ;):

-Motor:
*Opel C20LET, 2,0 16v turbo benzinac (od Kalibre Turbo)
*mapa/struja motora: EDS Fahrzeugtechnik GmbH, Phase 3 - 310ks/450Nm
*K&N filter za vazduh
*kovani klipovi
*stelujuce remenice
*usisna bregasta od C20XE (ostriji grebeni)
*injectors 470ccm/min
*hi-spec fuel pressure regulator
-hi-flow Bosch petrol pump
*boost controller
*veca usisna grana
*veca usisna kapa fi-60
*velike usisne cevi fi-60
*Bailey's Blow-Off Valve (BOV)
*veliki FMIC (front mounted intercooler)
*nosaci motora su ostali od motora X20XEV

-Menjac:
*Getrag F28 6-speed manual gearbox (od Calibre Turbo)
*hydraulic clutch
*2 piece axle shaft (dvodelna poluosovina od Calibre Turbo)
*pravljen je nosac za F28 menjac, jer nijedna Vektra B nikada nije imala taj menjac.

-Auspuh:
*ceo auspuh je custom, od prohroma, ukljucujuci i downpipe
*downpipe fi-90, flex pipe fi-80, posle cev fi-76, posle se deli na cevi 2x fi-60 do kraja
*prednji i srednji protocni lonac, plus dva zadnja protocna lonca
*2 dupla topa, cine trapez

-Vesanje:
*Eibach opruge
*samostelujuci amortizeri
*celo oslanjanje od Vectre i500
*Prednja uporna spona D&W (strut bar D&W doublepipe)

-Kocnice:
*set vecih prednjih kocionih diskova i klesta od Vectre i500 (308mm)
*kocioni cilindar od Vectre i500
 
ma men

ma men

Doppel-As
Dabei seit
25.05.2010
Beiträge
220
Ort
Kroatien
Vrhunske specifikacije!! Pogotovo mi se sviđa custom auspuh, sigurno nije bio jeftin, ali virujem da se isplatio.. ;(

*nosaci motora su ostali od motora X20XEV
*2 piece axle shaft (dvodelna poluosovina od Calibre Turbo)
Odlično! Ove dvije stvari su mi najviše tribale da mi potvrdiš, jer ja radim konverziju sa X16XEL na C20XE i koristim isto dvodjelnu poluosovinu, ali kad sam je prvi puta vidio mislio sam da neće pasat na šaraf... :151:
 
opcar

opcar

Mitglied
Themenstarter
Dabei seit
28.11.2010
Beiträge
32
Ort
Zemun, Serbien
Hi,

I know that you petrol heads, just like me, always like to see the whole process of modifying our cars (projects). Who knows, maybe somebody can get some good idea from the pics ;).

Since I entered forum here with the pretty much finished car, I want to show you few pics of project before - during - after. Enjoy 8):


Here are my 1997. Vectra CDX (pretty much everything possible except the sunroof) in a stock condition, apart from the wheels and restyling grille:







then came the OPC look phase:















... then came in the audio/video system:

















then came the LED lighting:





winter edition:





... up until that point, all was really just only the styling of the car ...

but then I made the decision to put in C20LET, turbo engine and F28, 6 speed gearbox:











so we started the project:













... and this was my meaning of transportation while I was waiting for my Veccy:

Opel Kadett GSi 2.0 16V





...and in the meantime, the project goes on:









... and on:

















....until finally:





... and then little more of styling:

rear diffuser:









...and "bad look":







...before repainting:











... and after:



carbon look roof:



finalizing:











fitting the exhaust system:











...finally:







...the car as it is today:




























...and here is the list of modifications :

Opel Vectra B Caravan:

-Engine:
*Opel C20LET, 2,0 16v turbo gasoline (from Calibra Turbo)
*ECU map: EDS Fahrzeugtechnik GmbH, Phase 3 -approx. 310HP/450Nm
*forged pistons
*adjustable cam pulleys (Vernier wheels)
*intake cam from C20XE
*fuel injectors 470ccm/min
*hi-spec fuel pressure regulator
*Bosch hi-flow petrol pump
*boost controller
*K&N cone air filter
*uprated inlet manifold
*uprated inlet hat diameter-60mm
*uprated intercooler pipes dia-60mm
*Bailey's Blow-Off Valve (BOV)
*(very) big FMIC (front mounted intercooler), mesh dimensions 230x550x65mm

-Gearbox:
*Getrag F28 6-speed manual gearbox (from Calibra Turbo)
*hydraulic clutch
*2 piece axle shaft (from Calibra Turbo)

-Exhaust:
*Custom, stainless steel, downpipe included
*downpipe dia-90mm, flex pipe dia-80mm, after that pipe dia-76mm, then separates into 2x dia-60mm to the end
*front and middle hi-flow mufflers, plus two rear hi-flow mufflers, then two double tailpipes

-Suspension:
*Eibach springs
*gas shock absorbers
*Vectra B i500 bushings, silent blocks, anti-sway bars, etc, etc, ...
*strut bar D&W doublepipe

-Wheels:
*studs & nuts
*locking nuts
summer:
*Opel 19" OPC (Snowflake) wheels, 8j×19" ET43
*5mm spacers per wheel,
*Maxxis 225/35/19 tyres (been on wheels, will be replaced)
winter:
*Opel 17" Intra (from Omega B) wheels, 7.5j×17" ET39
*Continental ContiWinterSport 205/50/17 tyres

-Brakes:
*Vectra B i500 front brake calipers and 308mm brake discs
*Vectra B i500 master brake cylinder

-Styling:
*the car is fully debadged (clean)
*Zender front bumper
*Zender rear bumper
*Zender top hat
*Zender back door strip
*Renault Espace 3 front lip
*custom rear diffuser and rear bumper skirts
*bad look (extended bonnet and wings)
*Kamei front grill and front bumper mesh
*widened wheel arches
*in.pro black side repeaters
*carbon look roof
*Fiat Bravo rear wiper
*irmscher trunk stainless steel strip
*chrome Vectra door sills
*chrome alu door pins
*Cobra Park Master parking sensor system
*front & rear drive camera
*llumar tinted windows

-Interior:
*Moman plasma tacho
*Audi S6 red pointers for tacho
*LED interior lights with master switch
*Raid HP steering wheel diameter-30cm
*Conrero alu pedals
*Conrero alu handle for hand brake
*Raid HP Night flight blue dials: for exhaust temperature, for fuel/air mixture, for turbo boost,
for oil pressure and for oil temperature
*Omega MV6 motorized rearview mirror with auto dimming function

-ICE:
*Sony Xplod XAV-W1, DVD, SACD, ... Head unit, 7 Inch, 5.1 surround system
*Sony Xplod XVM-R70, 7" flip-down Car Monitor, for rear seats
*Sony Xplod XS-HT170SN, Separate speakers front & rear channels
*Sony Xplod XS-HT130SN, Separate speaker center channel
*Sony Xplod XS-LD125P5, Dual voice coil subwoofer
*Sony Xplod XM-SD46X, Power amplifier front & rear channels
*Sony Xplod XM-SD12X, Power amplifier center channel
*Sony Xplod XM-SD22X, Power amplifier subwoofer
*Sony Xplod CDX-757MX, 10 CD/MP3 Changer
*Sony Xplod MDR-IF0140, Remote headphones x2
*Dietz & Neotech Power, signal & speaker cables
*Dynamat vibration absorbing mats + Diolen acoustic foam
*Dietz caps 1F x2
*Vision Gel Battery, second battery, only for Multimedia
*Dietz High Current relay
*Dietz digital voltmeter
*Dietz various connectors, fuses, splitters, etc, etc, ...


Cheers,
Danijel
 
Vectra148816V

Vectra148816V

Routinier
Dabei seit
25.06.2006
Beiträge
525
Alter
43
very Nice Vecci,

Sound Video :].????
 
Silver Arrow

Silver Arrow

Gelber Engel
Dabei seit
09.01.2006
Beiträge
3.061
Alter
45
Ort
RLP
Schönes Auto und super Fotos!
Ich fahre im Sommer nach Kroatien,Vielleicht trifft man sich ja mal.
Da ist ja ab und an auch mal ein Tuningtreffen.

Grüße


Nice Car and very good photos!
This Summer I make Holiday in Croatia,I hope to meet you there.
Sometimes there are Carmeetings too.

Greetings
 
opcar

opcar

Mitglied
Themenstarter
Dabei seit
28.11.2010
Beiträge
32
Ort
Zemun, Serbien
Hi Silver Arrow,

I'm very sorry for the late answer. Thank you very much for your kind words.

I'm looking forward to meet you in person in Croatia. I just hope that I'll be there in the same time as you. We'll keep in touch.

Best regards,
Danijel

- - - Aktualisiert - - -

Work in progress....



 
M

misterY

Schichtcheffe
Dabei seit
19.08.2006
Beiträge
1.870
You need sport seats :-)
 
mc_poodle

mc_poodle

Tripel-As
Dabei seit
09.10.2010
Beiträge
448
You did really well building this car, just as the photographer did a fantastic job.
 
Thema:

Vectra B Caravan Turbo

Vectra B Caravan Turbo - Ähnliche Themen

  • Vectra C Caravan 1.9 CDTI hört sich an wie trekker

    Vectra C Caravan 1.9 CDTI hört sich an wie trekker: Hallo, Ich bin neu hier und habe ein Problem. Vectra C Caravan 1.9 CDTI 150 PS BJ 2004. Kurze Vorgeschichte: Auto stand ca. 1 Jahr still weil zms...
  • Vectra C Caravan 2,0i Turbo 175PS - Erst.zul. - Vollleder schwarz

    Vectra C Caravan 2,0i Turbo 175PS - Erst.zul. - Vollleder schwarz: VERKAUFT! Fahrzeugbeschreibung Erstzul. 11/2003 KM-Stand: 106.500 (wird noch täglich gefahren!) TÜV/AU neu gemacht: bis 11/2016...
  • Ein Neuer ist im Forum

    Ein Neuer ist im Forum: Hi, bin der Neue, heiße Dennis und komm aus der Ecke Gö/Ks. Habn Vectra Caravan Sport und nen Astra Gsi turbo LG
  • Opel Vectra C Turbo laut? Opel Vectra C Caravan 1.9 CDTI 110KW 150 PS

    Turbo laut? Opel Vectra C Caravan 1.9 CDTI 110KW 150 PS: Hallo alle zusammen, ich hab seit kurzem ein pfeifen beim Gas geben, es wird immer stärker mit höheren Drehzahlen(Bj. 01/2005 99TKM)...
  • Ein neuer

    Ein neuer: Hallo. ich heiße Philipp, bin 29 Jahre alt und komme aus der Nähe von Osnabrück. Von Beruf bin ich Maurer / Stahlbetonbaumeister. Ich fahre einen...
  • Ein neuer - Ähnliche Themen

  • Vectra C Caravan 1.9 CDTI hört sich an wie trekker

    Vectra C Caravan 1.9 CDTI hört sich an wie trekker: Hallo, Ich bin neu hier und habe ein Problem. Vectra C Caravan 1.9 CDTI 150 PS BJ 2004. Kurze Vorgeschichte: Auto stand ca. 1 Jahr still weil zms...
  • Vectra C Caravan 2,0i Turbo 175PS - Erst.zul. - Vollleder schwarz

    Vectra C Caravan 2,0i Turbo 175PS - Erst.zul. - Vollleder schwarz: VERKAUFT! Fahrzeugbeschreibung Erstzul. 11/2003 KM-Stand: 106.500 (wird noch täglich gefahren!) TÜV/AU neu gemacht: bis 11/2016...
  • Ein Neuer ist im Forum

    Ein Neuer ist im Forum: Hi, bin der Neue, heiße Dennis und komm aus der Ecke Gö/Ks. Habn Vectra Caravan Sport und nen Astra Gsi turbo LG
  • Opel Vectra C Turbo laut? Opel Vectra C Caravan 1.9 CDTI 110KW 150 PS

    Turbo laut? Opel Vectra C Caravan 1.9 CDTI 110KW 150 PS: Hallo alle zusammen, ich hab seit kurzem ein pfeifen beim Gas geben, es wird immer stärker mit höheren Drehzahlen(Bj. 01/2005 99TKM)...
  • Ein neuer

    Ein neuer: Hallo. ich heiße Philipp, bin 29 Jahre alt und komme aus der Nähe von Osnabrück. Von Beruf bin ich Maurer / Stahlbetonbaumeister. Ich fahre einen...
  • Oben